Year · Make · Model
What the National Highway Traffic Safety Administration knows about this vehicle: every recall, every consumer complaint, every defect investigation, every NCAP crash test. Sourced directly from NHTSA data feeds.
THE SECTION THAT CARRIES THE POWER CABLES FROM THE BATTERIES TO THE ENGINE (CALLED THE "HAT" SECTION) COULD FRACTURE CAUSING THE MAIN POWER CABLE TO CHAFE.
FixTHE END SUPPORT WILL BE REMOVED FROM THE "HAT" SECTION AND A COMPONENT CALLED A STIFFENER WILL BE ADDED. ALSO, THE CABLES WILL BE REPOSITIONED, WITHOUT CHARGE TO OWNER.
THE SET-SCREW MAY NOT BE POSITIONED CORRECTLY, ALLOWING THE DRIVE KEY TO SLIDE OUT OF THE HUB AND THE HUB AND SPROCKET TO DISENGAGE. THIS WOULD CAUSE THE WHEELCHAIR PLATFORM TO FALL TO THE GROUND WITHOUT PRIOR WARNING.
FixWHEELCHAIR LIFT WILL BE INSPECTED FOR THE CORRECT POSITIONING OF THE SET-SCREW. IF NECESSARY, THE DRIVE KEY WILL BE TACK WELDED INTO THE DRIVE HEX WITHOUT CHARGE.
UNDER CERTAIN OPERATING ROAD CONDITIONS, THE POWER CABLES CONTAINED IN A TUBE BETWEEN THE BATTERIES AND THE ENGINE CAN MOVE FREELY. THIS MOVEMENT COULD CAUSE THE MAIN POWER CABLE TO CHAFE, LEADING TO AN ELECTRICAL SHORT.
FixTHE PRESENT WIRING CHANNEL WILL BE REPLACED AND INSULATING TYPE SUPPORTING BLOCKS WILL BE ADDED WITHOUT CHARGE TO OWNER.
CRACKS MAY DEVELOP IN THE TRUNNION TO WHICH THE APEX OF THE "A-FRAME" IS ATTACHED. THESE CRACKS MAY PROGRESS TO THE POINT THAT THE TRUNNION COULD FAIL AND THE A-FRAME COULD SEPARATE FROM IT. IF THIS OCCURS, THE A-FRAME COULD COME INTO CONTACT WITH THE CONDUIT CARRYING AIR, AS WELL AS THE ELECTRICAL AND FUEL LINES.
FixTRUNNION WILL BE INSPECTED FOR CRACKS AND, IF POSSIBLE, CRACKS WILL BE REPAIRED AS AN INTERIM MEASURE. ALL TRUNNIONS WILL BE REINFORCED BY GRUMMAN; ANY DEFORMED TRUNNIONS WILL BE REPLACED WITH A REINFORCED PART. REPAIRS WILL BE PERFORMED AT NO CHARGE.
ON CERTAIN VEHICLES, THE DRIVER"S BARRIER GLAZING WAS NOT MARKED AS SAFETY GLAZING MATERIAL. THIS DOES NOT MEET THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS".
FixFIELD SERVICE REPRESENTATIVES WILL INSTALL THE CORRECT DECALS AT NO CHARGE TO OWNERS.
THE POWER CABLES LEADING FROM THE BATTERIES OF THE INVOLVED VEHICLES ARE SUBJECT TO A CHAFING CONDITION, WHICH, IF UNDETECTED OR NOT CORRECTED CAN CAUSE WEAR TO THE CABLE INSULATION.
FixTO PREVENT CHAFING OF THE BATTERY CABLES, THE DEALER WILL INSTALL FOUR BATTERY CLAMPS, TWO EACH ON THE BATTERY HOLD DOWN BAR AND THE FUEL BOLSTER BRACKET, AND INSTALL PIECES OF RUBBER HOSE INSULATION ONTO THE LARGER POWER CABLES. THIS WILL BE DONE AT NO EXPENSE TO OWNER.
THE CHAIN DRIVE WELDMENT MAY FAIL UNDER A LIFT LOAD ALLOWING THE WHEELCHAIR PLATFORM TO FALL TO THE GROUND. ALSO, THE TOP KNUCKLE JOINT WELDMENT MAY CONTAIN DEFECTIVE WELDS.
FixMANUFACTURER WILL PROVIDE THE PARTS NECESSARY TO REPAIR WHEELCHAIR LIFTS AND WILL REIMBURSE FOR LABOR COSTS.
THE ALTERNATING CURRENT POWER WIRE, WHICH SUPPLIES POWER TO THE CONDENSER FAN MOTORS, MAY HAVE BEEN GROUNDED BY CHAFING OF THE INSULATION AGAINST THE CABLE CLAMP AND CLAMP CONTACT OF THE TRANSMISSION OIL FILTER FLEXLINE. THIS COULD CAUSE THE CONDENSER FAN MOTOR WIRE TO OVERHEAT.
FixTHE HARNESS AND POWER FEED WIRING WILL BE REROUTED AND THE CABLE CLAMPS WILL BE RELOCATED.
+ 5 more recalls. Pagination is on the roadmap.