1977 White Truck RC2

THE WINDSHIELD WIPER MAY OVER-TRAVEL ITS DESIGNED SWEEP ANGLE DURING ITS INITIAL STROKE WITH THE POSSIBILITY OF TEMPORARY WIPER IMMOBILIZATION.

FixDEALER WILL INSTALL A RESTRICTION FITTING IN THE CONTROL VALVE AT NO COST TO OWNER.

SOME OF THE VEHICLES MAY HAVE MANGANESE BRONZE SPRING CLIP PLATES USED AS A SUBSTITUTE FOR MALLEABLE IRON. THE SUBSTITUTE CLIPS, WHICH ARE USED TO ATTACH THE SUSPENSION SPRING TO THE REAR AXLE, MAY CRACK ALLOWING THE ASSEMBLY TO LOOSEN. THIS CAN CAUSE REAR AXLE DISPLACEMENT.

FixTHE DEALER WILL REPLACE THE MANGANESE BRONZE CLIPS WITH MALLEABLE IRON CLIP PLATES AT NO COST TO OWNER.

LOSS OF LIGHTS AND ENGINE SHUTDOWN MAY OCCUR AS A RESULT OF ELECTRICAL SYSTEM FAILURE DUE TO IMPROPER CIRCUIT CRIMPING AND POTENTIAL HEATER MOTOR CIRCUIT OVERLOADING. ALSO, THE FUEL SOLENOID MAY BE IMPROPERLY FUSED AND THE HEADLIGHT HARNESS IMPROPERLY ROUTED.

FixTHE DEALER WILL MAKE THE NECESSARY CORRECTIONS, FREE OF CHARGE TO THE OWNER.

THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", IN THAT SOME DUAL COMPARTMENT AIR RESERVOIRS WERE INSTALLED WITHOUT A DRAIN VALVE IN BOTH COMPARTMENTS. THE OMISSION OF THE DRAIN VALVE COULD CAUSE: 1) THE TANK TO FILL UP WITH WATER DUE TO CONDENSATION, 2) REDUCED AIR VOLUME, 3) CONTAMINATION OF THE AIR SYSTEM WITH WATER, CAUSING MALFUNCTION OF THE RELEASE VALVES, CHECK VALVES, ETC., AND INCREASING THE POSSIBILITY OF AIR SYSTEM COMPONENT FREEZE-UP IN COLD CLIMATES. THESE CONDITIONS COULD RESULT IN MOMENTARY LOSS OF BRAKING ACTION.

FixDEALER WILL INSPECT AND, IF NECESSARY, INSTALL A DRAIN VALVE AT NO COST TO OWNER.

THE VINYL COVERED INTERIOR PASSENGER ASSIST/GRAB HANDLE LOCATED ON THE RIGHT HAND HINGE PILLAR CAN WEAR AND FAIL IN SERVICE.

FixTHE OWNER HAS THE OPTION OF EITHER HAVING THE DEALER REMOVE THE HANDLE FREE OF CHARGE OR REMOVING IT HIMSELF AND BEING REIMBURSED $3.00 PER VEHICLE.

THE INVOLVED VEHICLES MAY HAVE BEEN BUILT WITH POWER UNIT ANTI-SKID LOGIC MODULES ON TAG AXLE INSTALLATIONS INSTEAD OF THE CORRECT TRAILER TYPE MODULES. SINCE THE TAG AXLE SENSOR OUTPUT IS LESS THAN THAT OF THE POWER UNIT SENSOR, IT REQUIRES THE MORE SENSITIVE TRAILER MODULE. AS SENSOR OUTPUT OVER TIME DROPS BELOW MINIMUM REQUIREMENTS, ONE OF TWO THINGS WILL HAPPEN: (1) THE ANTI-LOCK SYSTEM ON THE TAG AXLE WILL SHUT DOWN AND THE CAB MOUNTED FAULT LAMP WILL LIGHT OR (2) THE SYSTEM WILL BECOME INOPERATIVE WITHOUT ACTIVATING THE FAULT LIGHT. THIS FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKES".

FixDEALER WILL REPLACE THE INCORRECT ANTI-LOCK MODULE WITHOUT CHARGE TO OWNER.

DUE TO LOCATION OF THE BACK OF THE CAB REFLECTOR BEING ABOVE THE 60-INCH MAXIMUM HEIGHT, REFLECTORS WERE TO BE INSTALLED ON THE REAR FRAME CROSSMEMBER. SOME OF THESE TRUCKS WERE DELIVERED WITHOUT THE FRAME MOUNTED REFLECTORS. AS A RESULT, THESE VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT".

FixDEALER WILL INSPECT AND, IF NECESSARY, INSTALL THE REQUIRED REFLECTORS, WITHOUT CHARGE TO OWNER.

THE INVOLVED VEHICLES MAY BE IN NON-COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS", DUE TO OMISSION OF THE DRIVER"S SEAT UNDER-CAB SUPPORTS. AS A RESULT, THE DRIVER"S SEAT MAY EVENTUALLY COME LOOSE.

FixTHE PROPER SUPPORTS WILL BE INSTALLED, WITHOUT CHARGE.