1977 White Truck RB2

LOCKWASHERS, USED TO RETAIN THE ENGINE"S FAN MOUNTING BOLTS, MAY HAVE BEEN OMITTED DURING ASSEMBLY, CAUSING THE BOLTS TO LOOSEN AND ALLOWING THE FAN TO SEPARATE FROM ITS MOUNTING HUB.

FixDEALER WILL INSTALL LOCKWASHERS ON THE BOLTS.

THE METAL STIFFENER AT THE REAR OF THE SPLASH SHIELD MAY BECOME BENT DURING SERVICING OR BY ABUSE. THIS CAN ALLOW THE SPLASH SHIELD AND STIFFENER OR ONE OF ITS ATTACHING BOLTS TO RUB AGAINST AND CUT THE STEERING SHAFT.

FixTHE SPLASH SHIELD STIFFENER WILL BE REMOVED AND THE STEERING SHAFT WILL BE REPLACED, IF DAMAGED.

THE WINDSHIELD WIPER MAY OVER-TRAVEL ITS DESIGNED SWEEP ANGLE DURING ITS INITIAL STROKE WITH THE POSSIBILITY OF TEMPORARY WIPER IMMOBILIZATION.

FixDEALER WILL INSTALL A RESTRICTION FITTING IN THE CONTROL VALVE AT NO COST TO OWNER.

SOME OF THE VEHICLES MAY HAVE MANGANESE BRONZE SPRING CLIP PLATES USED AS A SUBSTITUTE FOR MALLEABLE IRON. THE SUBSTITUTE CLIPS, WHICH ARE USED TO ATTACH THE SUSPENSION SPRING TO THE REAR AXLE, MAY CRACK ALLOWING THE ASSEMBLY TO LOOSEN. THIS CAN CAUSE REAR AXLE DISPLACEMENT.

FixTHE DEALER WILL REPLACE THE MANGANESE BRONZE CLIPS WITH MALLEABLE IRON CLIP PLATES AT NO COST TO OWNER.

THE HOSE CLAMP, WHICH WAS INSTALLED AROUND THE STEERING COLUMN BOOT SEAT TO KEEP NOISE AND DIRT FROM ENTERING THE CAB, MAY LOOSEN.

FixDEALER WILL REPLACE THE METAL HOSE CLAMP WITHOUT CHARGE.

LOSS OF LIGHTS AND ENGINE SHUTDOWN MAY OCCUR AS A RESULT OF ELECTRICAL SYSTEM FAILURE DUE TO IMPROPER CIRCUIT CRIMPING AND POTENTIAL HEATER MOTOR CIRCUIT OVERLOADING. ALSO, THE FUEL SOLENOID MAY BE IMPROPERLY FUSED AND THE HEADLIGHT HARNESS IMPROPERLY ROUTED.

FixTHE DEALER WILL MAKE THE NECESSARY CORRECTIONS, FREE OF CHARGE TO THE OWNER.

THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", IN THAT SOME DUAL COMPARTMENT AIR RESERVOIRS WERE INSTALLED WITHOUT A DRAIN VALVE IN BOTH COMPARTMENTS. THE OMISSION OF THE DRAIN VALVE COULD CAUSE: 1) THE TANK TO FILL UP WITH WATER DUE TO CONDENSATION, 2) REDUCED AIR VOLUME, 3) CONTAMINATION OF THE AIR SYSTEM WITH WATER, CAUSING MALFUNCTION OF THE RELEASE VALVES, CHECK VALVES, ETC., AND INCREASING THE POSSIBILITY OF AIR SYSTEM COMPONENT FREEZE-UP IN COLD CLIMATES. THESE CONDITIONS COULD RESULT IN MOMENTARY LOSS OF BRAKING ACTION.

FixDEALER WILL INSPECT AND, IF NECESSARY, INSTALL A DRAIN VALVE AT NO COST TO OWNER.

THE VINYL COVERED INTERIOR PASSENGER ASSIST/GRAB HANDLE LOCATED ON THE RIGHT HAND HINGE PILLAR CAN WEAR AND FAIL IN SERVICE.

FixTHE OWNER HAS THE OPTION OF EITHER HAVING THE DEALER REMOVE THE HANDLE FREE OF CHARGE OR REMOVING IT HIMSELF AND BEING REIMBURSED $3.00 PER VEHICLE.