1993 Thomas Vista

VEHICLE DESCRIPTION: SCHOOL BUSES BUILT ON A NAVISTAR CHASSIS. THE CROSS VIEW MIRRORS DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 111, "REARVIEW MIRRORS." THE ENTIRE TOP SURFACE OF CYLINDER H IS NOT VISIBLE AS REQUIRED.

RiskA DRIVER MAY NOT BE ABLE TO SEE CERTAIN PORTIONS OF THE BUS INCREASING THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS NEAR THE BUS.

FixOWNERS WILL BE PROVIDED WITH A REPAIR KIT AND DETAILED INSTRUCTIONS. IF AN OWNER SO DESIRES, THOMAS BUILT DEALERS CAN PERFORM THE REPAIR FOR THEM.

AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT IN THE AREA BETWEEN THE SERVICE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET.

RiskIF AN ITEM WORN BY A CHILD WERE TO CATCH ON THIS AREA, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, THIS CAN RESULT IN SERIOUS INJURY OR DEATH.

FixA MOLDED COVER WILL BE INSTALLED BETWEEN THE MANUALLY OPERATED OUTWARD OPENING ENTRANCE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET WHICH WILL ELIMINATE THE OPENING THAT COULD ALLOW AN ITEM OF A CHILD'S CLOTHING TO BECOME SNAGGED.

AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY CAN BECOME CAUGHT IN A SMALL OPENING AT THE FLOOR LEVEL OF THE FORWARD DOOR POST.

RiskA PASSENGER'S CLOTHING COULD BECOME CAUGHT IN THE SMALL OPENING AND IF THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THE INDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUS INJURY OR DEATH.

FixA FILLER PLATE WILL BE ATTACHED ON THOMAS CONVENTIONALS OR A PIECE OF RUBBER TRIM ON THOMAS VISTAS TO THE FORWARD DOOR POST AT THE FLOOR LEVEL TO COVER THE OPENING AND ELIMINATE THE POSSIBILITY OF SNAGGING.

IF PAPER OR TRASH FALLS DOWN THE RED DOT HEATER VENTS IT COULD IGNITE.

RiskTHIS CONDITION CAN CAUSE A HEATER FIRE AND AN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.

FixDEALERS WILL INSTALL A WIRE CAGE AROUND THE HEATER RESISTOR.

THE BRACKET USED TO SUPPORT THE HYDRAULIC BRAKE LINE CAN CRACK AND POSSIBLY SEVER THE BRAKE LINE.

RiskIF THE BRAKE LINE IS SEVERED, BRAKING CAPABILITY WILL BE IMMEDIATELY REDUCED, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

FixDEALERS WILL REROUTE THE HYDRAULIC BRAKE LINE.

THE METAL HOUSING OF THE SAFETY BELT RETRACTORS ON AUTOMATIC LOCKING RETRACTOR/EMERGENCY LOCKING RETRACTOR SAFETY BELTS CAN BECOME DEFORMED PREVENTING EXTENSION AND/OR RETRACTION OF THE BELT.

RiskPASSENGERS WOULD BE UNABLE TO EXTEND OR RETRACT THEIR SAFETY BELTS AND WOULD BE AT A RISK OF INJURY IN THE EVENT OF AN ACCIDENT.

FixDEALERS WILL INSTALL A HARDENED WASHER WHICH WILL DECREASE THE POSSIBILITY OF DEFORMATION OF THE SAFETY BELT RETRACTOR. DAMAGED RETRACTORS WILL BE REPLACED.

THE CURRENT PRODUCTION STATIONARY WINDOW ASSEMBLIES ALLOW THE GLASS TO DISENGAGE FROM THE RUBBER AND/OR FRAME.

RiskTHE WINDOWS DO NOT COMPLY WITH FMVSS 217, "BUS WINDOWRETENTION AND RELEASE."

FixINSTALL TWO RETAINING CLIPS AT EACH NON-COMPLYING WINDOW.