2000 Thomas MVP ER

DAIMLER TRUCKS IS RECALLING 3,773 MY 1996 THROUGH 2002 THOMAS BUILT MVP ER SCHOOL BUSES MANUFACTURED FROM JUNE 8, 1995 THROUGH FEBRUARY 16, 2001, EQUIPPED WITH CATERPILLAR 3116 AND 3126 ENGINES. UN-FUSED POWER CABLES WERE TIE-WRAPPED TO A WIRE BRAID ENGINE FUEL RETURN HOSE. OVER TIME THESE CABLES MAY CHAFE, WEARING THROUGH THE WIRE LOOM AND EVENTUALLY THROUGH THE CABLE INSULATION AND FUEL LINE COVERING IN AN AREA NOT EASILY DETECTABLE DURING NORMAL MAINTENANCE WITHOUT REMOVING THE TIE WRAPS AND OPENING THE WIRE LOOM. UN-FUSED AND UN-SWITCHED POWER CABLES WHICH WEAR THROUGH AND CONTACT THE FUEL LINE WIRE BRAID MAY SHORT CIRCUIT.

RiskIN THE EVENT OF A SHORT CIRCUIT, A VEHICLE FIRE CAN OCCUR.

FixTHOMAS BUILT WILL NOTIFY OWNERS AND INSPECT AND REPLACE THE CABLES AS NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 28, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.

RiskIN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.

FixDAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

CERTAIN MY 2000 THROUGH 2003 THOMAS BUILT HDX AND MVP-ER SCHOOL BUSES MANUFACTURED BETWEEN APRIL 23, 2000, AND NOVEMBER 14, 2003. THE SERVICE AIR BRAKE PEDAL, FOR BOTH NON-ADJUSTABLE AND ADJUSTABLE BRAKE PEDALS, MAY CONTACT THE FRONT STRUCTURE ON THE BUS, LIMITING THE MAXIMUM BRAKE FORCE AVAILABLE.

RiskINSUFFICIENT AIR BRAKE PRESSURE MAY CAUSE EXTENDED STOPPING DISTANCES WITHOUT PRIOR WARNING, POSSIBLY RESULTING IN A VEHICLE CRASH.

FixTHOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE AFFECTED BUSES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS CAN CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.

CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.

RiskSHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.

FixCUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.

ON CERTAIN SCHOOL OR TRANSIT BUSES WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AMSAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.

RiskIF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY.

FixDEALERS WILL PROVIDE A PLASTIC OUTER COVER THAT SNAPS OVER THE EXISTING COVER ON UNITS IN THE FIELD AND WILL REPLACE BROKEN SEAT BELTS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-841-5924 OR AMSAFE AT 574-266-8330.

ON CERTAIN SCHOOL AND TRANSIT BUSES, THE WHEEL LUG NUT MAY NOT TIGHTEN COMPLETELY.

RiskTHE WHEEL COULD LOOSEN INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

FixDEALERS WILL INSTALL NEW WHEEL STUDS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-889-4871.

ON CERTAIN SCHOOL BUSES, MISALIGNMENT OF THE FAN DRIVE SYSTEM COMPONENTS CAN CAUSE PREMATURE BELT AND PULLEY BEARING WEAR.

RiskIF THE SCHOOL BUS IS DISABLED BY A COOLING SYSTEM FAILURE AND IS STALLED ON THE SIDE OF THE ROAD, AN INCREASED RISK OF A CRASH RESULTING IN INJURY TO A SCHOOL BUS OCCUPANT COULD OCCUR.

FixDEALERS WILL REPLACE THE FAN BELT, IDLER PULLEY, AND BELT TENSIONER AND THE PULLEY'S LASER WILL BE ALIGNED. OWNER NOTIFICATION BEGAN JUNE 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

RiskSERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

FixAM-SAFE NOTIFIED THOMAS BUILT'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 21, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.

EMERGENCY DOOR HANDLE FAILURE

Led to recall08V087000

RESTRICTED BRAKE PEDAL MOVEMENT

Led to recall07V137000

FAN DRIVE UPDATE

Led to recall02V085000