2022 Thomas Built Buses SAF-T-LINER C2

Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2019-2022 Saf-T-Liner C2, Saf-T-Liner EFX, Saf-T-Liner HDX, Minotour DRW, 2020-2022 Saf-T-Liner C2 Jouley, and Minotour SRW school buses. The Emergency Exit Label lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 217, "Bus Emergency Exits and Window Retention and Release."

RiskEmergency exit labels that are difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

FixDealers will correct the lettering, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL918.

Daimler Trucks North America, LLC. (DTNA) is recalling certain 2019-2024 Thomas Built SAF-T-LINER C2 transit buses. The fasteners for the emergency exit door may loosen and detach, which can allow the emergency exit door to open unexpectedly.

RiskAn emergency exit door opening unexpectedly can increase the risk of an injury.

FixDealers will inspect and tighten the fasteners for the emergency exit door, as necessary, free of charge. Owner notification letters were mailed December 1, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL982.

Daimler Trucks North America, LLC. (DTNA) is recalling certain 2019-2024 Thomas Built SAF-T-LINER C2 and 2020-2024 Thomas Built SAF-T-Liner Jouley school buses. The fasteners for the emergency exit door may loosen and detach, which can allow the emergency exit door to open unexpectedly.

RiskAn emergency exit door opening unexpectedly can increase the risk of an injury.

FixDealers will inspect and tighten the fasteners for the emergency exit door, as necessary, free of charge. Owner notification letters were mailed December 1, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL982.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2023 Thomas Built Bus SAF-TLINER C2 JOULEY school buses equipped with an automatic low voltage disconnect switch. The automatic low voltage disconnect switch may fail, resulting in a loss of drive power, power steering, or vehicle lighting.

RiskA loss of drive power, power steering, or vehicle lighting can increase the risk of a crash.

FixDealers will remove the automatic low voltage disconnect switch, free of charge. Owner notification letters were mailed October 18, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL968.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2024 Thomas Built SAF-T-LINER C2 and 2021-2023 Thomas Built SAF-T-LINER C2 Jouley school buses.  A rear interior joint may have been manufactured incorrectly, resulting in insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

RiskA school bus with insufficient joint strength may not adequately protect passengers in the event of a crash, increasing the risk of injury.

FixDealers will add additional fasteners to secure the joints, free of charge. Owner notification letters were mailed December 19, 2023. Owners may contact DTNA customer service at 1-800-574-0712. DTNA's number for this recall is FL973.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2023 Thomas Built C2 Saf-T-Liner school buses equipped with 8.8L LPG engines. The engine control module (ECM) may set a fault code that results in an unexpected engine shut down.

RiskUnexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.

FixDealers will update the ECM software, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL942.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022 Thomas Built Saf-T-Liner C2 school buses. The gas pedal may be misaligned and wear a hole into the floor mat, which can trap the gas pedal.

RiskA trapped gas pedal will not allow the vehicle to decelerate as expected when the driver lifts their foot from the gas pedal, resulting in unintended acceleration and an increased risk of a crash.

FixDealers will inspect and replace the gas pedal assembly as necessary, free of charge. Owner notification letters are expected to be mailed February 5, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL913.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022 Thomas Built Saf-T-Liner C2 school buses. The gas pedal may be misaligned and wear a hole into the floor mat, which can trap the gas pedal.

RiskA trapped gas pedal will not allow the vehicle to decelerate as expected when the driver lifts their foot from the gas pedal, resulting in unintended acceleration and an increased risk of a crash.

FixDealers will inspect and replace the gas pedal assembly as necessary, free of charge. Owner notification letters are expected to be mailed February 5, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL913.