2021 Thomas Built Buses SAF-T-LINER C2 Jouley

Daimler Trucks North America, LLC (DTNA) is recalling certain Thomas Built Buses 2019-2022 Saf-T-Liner C2, Saf-T-Liner EFX, Saf-T-Liner HDX, Minotour DRW, 2020-2022 Saf-T-Liner C2 Jouley, and Minotour SRW school buses. The Emergency Exit Label lettering is too small and may be difficult to read. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 217, "Bus Emergency Exits and Window Retention and Release."

RiskEmergency exit labels that are difficult to read can prevent or delay the use of the emergency exit, increasing the risk of injury.

FixDealers will correct the lettering, free of charge. Owner notification letters were mailed September 5, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL918.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2025 Thomas Built SAF-T-LINER C2 Jouley electric school buses. The high voltage inverter cable may not be secured properly, which can result in a loss of drive power.

RiskA loss of drive power can increase the risk of a crash.

FixDealers will inspect and tighten the fasteners as necessary, free of charge. Owner notification letters were mailed starting February 1, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL987.

Daimler Trucks North America, LLC. (DTNA) is recalling certain 2019-2024 Thomas Built SAF-T-LINER C2 and 2020-2024 Thomas Built SAF-T-Liner Jouley school buses. The fasteners for the emergency exit door may loosen and detach, which can allow the emergency exit door to open unexpectedly.

RiskAn emergency exit door opening unexpectedly can increase the risk of an injury.

FixDealers will inspect and tighten the fasteners for the emergency exit door, as necessary, free of charge. Owner notification letters were mailed December 1, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL982.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2024 Thomas Built SAF-T-LINER C2 and 2021-2023 Thomas Built SAF-T-LINER C2 Jouley school buses.  A rear interior joint may have been manufactured incorrectly, resulting in insufficient joint strength. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 221, "School Bus Body Joint Strength."

RiskA school bus with insufficient joint strength may not adequately protect passengers in the event of a crash, increasing the risk of injury.

FixDealers will add additional fasteners to secure the joints, free of charge. Owner notification letters were mailed December 19, 2023. Owners may contact DTNA customer service at 1-800-574-0712. DTNA's number for this recall is FL973.

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2023 FCCC Saf-T-Liner C2 Jouley Electric Buses. A high voltage battery cable may not be properly connected, which can cause a loss of electrical power or a ground short circuit.

RiskUnexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers. A ground short circuit can increase the risk of a fire.

FixAll vehicles have been remedied, therefore no owner notification letters are necessary. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL939.