2010 Starcraft Ultrastar

Starcraft Bus is recalling certain model year 2010-2013 Allstar XL, Ultrastar, Allstar, Starlite, Starquest, Xpress, Prodigy, Quest, and Allstar MVP transit buses built on Ford cutaway chassis equipped with Ford 5.4L or 6.8L engines and Trans/Air-brand air compressors. In the affected vehicles, depending on the routing of the alternator harness, and the orientation of the heater hose spring clamp at the front of the intake manifold, the alternator harness may be pinched between the spring clamp and the air conditioner compressor mounting bracket.

RiskThe charging system may fail which could lead to the vehicle stalling while driving, increasing the risk of a crash. Additionally, the spring clamp could pierce both the positive and negative wires of the alternator harness creating a short circuit which could result in a fire.

FixStarcraft Bus will notify owners, and dealers will inspect the vehicles, correct the clamp installation and repair and reroute the alternator harness, as needed, free of charge. The recall began on February 19, 2014. Customers may contact Starcraft at 1-800-347-7440.

STARCRAFT IS RECALLING CERTAIN MODEL YEAR 2006-2010 BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

RiskA WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

FixSTARCRAFT WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. OWNERS MAY CONTACT STARCRAFT BUS AT 1-800-347-7440.

STARCRAFT IS RECALLING CERTAIN MODEL YEAR 2006 AND 2007 TRANSIT BUSES BUILT ON FORD AND FREIGHTLINER CHASSIS AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

RiskIF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

FixSTARCRAFT WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN IN NOVEMBER 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-348-7440.