Year · Make · Model

2008 NEW Flyer D40LF

What the National Highway Traffic Safety Administration knows about this vehicle: every recall, every consumer complaint, every defect investigation, every NCAP crash test. Sourced directly from NHTSA data feeds.

Open recalls

NHTSA complaints

Defect investigations

Service bulletins

Recalls

7 campaigns

12V591000·STRUCTURE2012-12-17

New Flyer is recalling certain model year 2004-2011 transit buses, models: C35LF, C40LFR, D35LFR, D40LF, D40LFR, D60LF, D60LFA, D60LFR, DE35LFA, DE40LF, DE40LFA, DE40LFR, DE60LF, DE60LFA, DE60LFR, and XDE40. The drive shaft access panel may have insufficient strength or be not properly secured to the floor. If the drive shaft fails, debris from the driveshaft failure may enter the passenger compartment through the panel.

RiskIf debris resulting from drive shaft failure enters the passenger compartment, it may result in injury to the bus occupants.

FixNew Flyer notification to owners on 01/03/2013. Dealers will install a steel plate under the access panel on affected buses, free of charge. Owners may contact New Flyer at 1-204-224-6706 for more information.

11V237000·LATCHES/LOCKS/LINKAGES:DOORS:LATCH2011-04-14

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2007-2011 LOW FLOOR TRANSIT BUSES PRODUCED FROM MAY 24, 2007, THROUGH MARCH 1, 2011 AND EQUIPPED WITH TEETER LEVER ASSEMBLIES. THERE IS INSUFFICIENT ENGAGEMENT BETWEEN THE TEETER LEVER BASE AND THE CAM PLATE.

RiskFAILURE OF THE TEETER LEVER ASSEMBLY WILL CAUSE THE REAR SIDE EXIT DOOR TO OPERATE IMPROPERLY. A PASSENGER LEANING ON OR FORCED AGAINST THE DOOR COULD FALL THROUGH THE DOOR AND SUSTAIN INJURIES.

FixNEW FLYER IS WORKING WITH THE MANUFACTURER OF THE TEETER LEVER ASSEMBLIES, VAPOR BUS, TO REPAIR THE AFFECTED BUSES FREE OF CHARGE. PLEASE SEE VAPOR BUS DEFECT REPORT 11E-010. THE SAFETY RECALL BEGAN ON APRIL 29, 2011. OWNERS MAY CONTACT VAPOR BUS AT 1-847-777-6450 OR NEW FLYER CUSTOMER SERVICES AT 1-204-934-4874.

10V605000·POWER TRAIN:AXLE ASSEMBLY2010-11-29

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2008-2009 HEAVY DUTY TRANSIT BUSES. THE RADIUS ROD BRACKET WHICH ATTACHES THE FRONT AXLE RADIUS RODS TO THE VEHICLE FRAME MAY BE MISSING TWO OF THE FOUR REQUIRED WELDS.

RiskFAILURE OF A RADIUS ROD BRACKET ASSEMBLY MAY RESULT IN RESTRICTED STEERING CAPABILITY INCREASING THE RISK OF VEHICLE CRASH, INJURY OR DEATH.

FixDEALERS WILL INSPECT FOR RADIUS ROD BRACKETS AND WILL BE REPLACED WITH CERTIFIED PRODUCT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4876.

10V343000·EQUIPMENT2010-07-22

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2008 C40LFR, D40LF AND DE60LF HEAVY DUTY TRANSIT BUSES, AS WELL AS MODEL YEAR 2009 DE60LFA HEAVY DUTY TRANSIT BUSES. THE PASSENGER ASSIST GRAB STRAP HANDLES HAVE EXPERIENCED MULTIPLE FAILURES IN THE FIELD.

RiskFAILURE OF A PASSENGER ASSIST GRAB STRAP HANDLE COULD RESULT IN A PASSENGER FALLING AND BEING INJURED.

FixDEALERS WILL REPLACE THE EXISTING PASSENGER ASSIST GRAB STRAP HANDLES WITH AN IMPROVED PRODUCT FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4876.

10V089000·POWER TRAIN:DRIVELINE:DRIVESHAFT2010-03-09

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE.

RiskFAILURE OF THE DRIVE SHAFT ACCESS PANEL TO MAINTAIN PASSENGER COMPARTMENT INTEGRITY COULD RESULT IN INJURY OR DEATH.

FixDEALERS WILL INCORPORATE AN ENERGY ABSORBING HONEYCOMB MATERIAL TO THE UNDERSIDE OF THE ACCESS PANEL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 10, 2010. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.

09V367000·INTERIOR LIGHTING2009-09-24

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

RiskA SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.

FixNEW FLYER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER2, 2009. OWNERS MAY CONTACT NEW FLYER CUSTOMER SERVICES AT 1-204-934-4876.

08V296000·SERVICE BRAKES, AIR2008-07-03

NEW FLYER IS RECALLING 319 MY 2008 C40LF, C40LFR, D35LF, D40LF, D41LF, D61LFR, DE41LF, DE61LF, E40LFR, GE40LFR, AND DE41LFR TRANSIT BUSES EQUIPPED WITH PARKER HANNIFIN (VANSCO) CONTROL MODULES. A CERTAIN BATCH OF THE PROGRAMMABLE LOGIC CONTROL MODULES MAY HAVE A MANUFACTURING DEFECT. THIS DEFECT COULD PRODUCE ERRATIC BEHAVIOR OF CERTAIN INPUT/OUTPUT SIGNALS TO AND FROM THE AFFECTED MODULE. THIS ERRATIC BEHAVIOR COULD POTENTIALLY IMPACT CERTAIN FUNCTIONS SUCH AS THE HEADLIGHTS, BRAKE LIGHTS, THROTTLE CONTROL, AND CONTROL OF THE ARTICULATED JOINT.

RiskFAILURE OF THE MODULE TO PROPERLY CONTROL THE VEHICLE SUB-SYSTEMS COULD RESULT IN VEHICLE CRASH, INJURY OR DEATH.

FixTHE AFFECTED MODULES WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JULY 14, 2008. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.

← home