2004 NEW Flyer C40LF

NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

RiskA SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.

FixNEW FLYER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER2, 2009. OWNERS MAY CONTACT NEW FLYER CUSTOMER SERVICES AT 1-204-934-4876.

CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.

RiskTHE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.

FixDEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.

ON CERTAIN TRANSIT BUSES, THE SPOT WELDS WHICH HOLD THE WHEELCHAIR RAMP HINGE ASSEMBLY TOGETHER CAN FAIL ALLOWING THE RAMP TO SEPARATE, WHEN DEPLOYED UNDER LOAD, FROM THE BUS FRAME.

RiskSEPARATION OF THE RAMP FROM THE VEHICLE COULD RESULT IN INJURY TO PASSENGERS ON THE RAMP.

FixDEALERS WILL ADD NEW HARDWARE TO THE HINGES WHICH WILL MAKE THE SPOT-WELDING REDUNDANT. THE RECALL BEGAN ON FEBRUARY 15, 2006. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.

ON CERTAIN TRANSIT BUSES EQUIPPED WITH RELAY VALVES BUILT BY HALDEX/MIDLAND AND DISTRIBUTED BY MERITOR/WABCO WITH VALVE BODY DATE CODE OF 342A4K. THIS VALVE, WHICH IS INSTALLED IN THE REAR AXLE AIR BRAKE CIRCUIT, CAN FAIL RESULTING IN A LOSS OF AIR PRESSURE TO THE REAR SERVICE BRAKES.

RiskFAILURE OF THE VALVE WOULD DISABLE THE REAR AXLE SERVICE BRAKE CIRCUIT AND RESULT IN EXTENDED STOPPING DISTANCES WHICH COULD RESULT IN A CRASH.

FixDEALERS WILL INSPECT TO SEE IF THE INSTALLED RELAY VALVE HAS A DATE CODE OF 342A4K AND IF NECESSARY WILL REPLACE THE VALVE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT NEW FLYER AT 204-934-4803.

ON CERTAIN TRANSIT BUSES, HYDRAULIC FLUID CAN LEAK AT THE FLANGE FITTING DUE TO IMPROPER INSTALLATION PROCEDURES. INCORRECT INSTALLATION PROCEDURES MAY CAUSE DAMAGE TO THE O-RING OF THE FLANGE ASSEMBLY, COMPROMISING THE SEALING CAPABILITY OF THE O-RING.

RiskLEAKS CAUSED DUE TO DAMAGED O-RINGS COULD CAUSE HYDRAULIC FLUID TO BE SPRAYED ONTO HOT SURFACES AND IGNITE.

FixNEW FLYER WILL CONTACT CUSTOMERS WITH PARTS AND INSTRUCTIONS ON HOW TO COMPLETE THIS RECALL. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.

ON CERTAIN TRANSIT BUSES EQUIPPED WITH MERITOR FRONT AXLE ASSEMBLIES, A WELD IS MISSING ON THE RADIUS ROD ATTACHMENT BRACKETAND THE BRACKET MAY FATIGUE AND FAIL WHILE IN USE.

RiskBRACKET FAILURE COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.

FixDEALERS WILL REPLACE THE BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 6, 2005. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.