2007 Mitsubishi Fuso FM64F

MITSUBISHI FUSO TRUCK OF AMERICA (MFTA) IS RECALLING 156 HALOGEN SEALED BEAM HIGH BEAM HEADLAMP ASSEMBLIES SOLD BETWEEN OCTOBER 24, 2007 AND DECEMBER 2, 2008 FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN MITSUBISHI FUSO TRUCKS. THESE LAMPS FAIL TO CONFORM TO THE SAE STANDARDS OR RECOMMENDED PRACTICES REFERENCED IN TABLE I OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

RiskTHE PURPOSE OF THIS STANDARD IS TO REDUCE DEATHS AND INJURIES FROM MOTOR VEHICLE CRASHES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

FixMFTA WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 15, 2009. OWNERS MAY CONTACT MFTA AT 1-856-467-4500.

ON CERTAIN TRUCKS, THE VIN LABEL WAS PRINTED WITH AN IMPROPER GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATING (GAWR) FOR BOTH THE FRONT AND REAR AXLES.

RiskTHE MANUFACTURER HAS NOT YET PROVIDED A CONSEQUENCE FOR THIS CAMPAIGN.

FixDEALERS WILL REPLACE THE VIN LABELS WITH CORRECTED GVWR AND GAWR VALUES FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-4500.

ON CERTAIN TRUCKS, AN EXCESSIVE AMOUNT OF WELD MATERIAL MAY BE PRESENT ON THE REAR AXLE HOUSING AT THE JOINT RETAINER. THE CLEARANCE BETWEEN THE JOINT RETAINER AND BRAKE CONNECTOR MAY BE BEYOND SPECIFICATION AND COULD CAUSE THE ATTACHING BOLT TO LOOSEN ALLOWING THE BRAKE PIPE TO VIBRATE.

RiskTHE BRAKE PIPE COULD CRACK, ALLOWING BRAKE FLUID TO LEAK, DECREASING BRAKING PERFORMANCE AND CAUSING A CRASH WITHOUT WARNING.

FixDEALERS WILL INSPECT AND REMOVE EXCESSIVE WELD MATERIAL AND REPAIR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 14, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-3917.