2005 Mitsubishi Fuso FM64F

MITSUBISHI FUSO TRUCK OF AMERICA (MFTA) IS RECALLING 156 HALOGEN SEALED BEAM HIGH BEAM HEADLAMP ASSEMBLIES SOLD BETWEEN OCTOBER 24, 2007 AND DECEMBER 2, 2008 FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN MITSUBISHI FUSO TRUCKS. THESE LAMPS FAIL TO CONFORM TO THE SAE STANDARDS OR RECOMMENDED PRACTICES REFERENCED IN TABLE I OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

RiskTHE PURPOSE OF THIS STANDARD IS TO REDUCE DEATHS AND INJURIES FROM MOTOR VEHICLE CRASHES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.

FixMFTA WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 15, 2009. OWNERS MAY CONTACT MFTA AT 1-856-467-4500.

ON CERTAIN TRUCKS, THE AUTOMATIC TRANSMISSION (A/T) SELECTOR LEVER MAY HAVE BEEN IMPROPERLY MACHINED ALLOWING EXCESSIVE PLAY IN THE LEVER, CAUSING IMPROPER ENGAGEMENT OF THE "P" RANGE (PARK).

RiskTHE TRANSMISSION COULD REMAIN IN THE "R" RANGE (REVERSE) AFTER SHIFTING THE VEHICLE INTO PARK ALLOWING THE VEHICLE TO ROLL, CAUSING A CRASH WITHOUT WARNING.

FixDEALERS WILL REPLACE THE A/T CONTROL LEVER ASSEMBLY, A/T SHIFT CONTROL CABLE AND PROPER PARKING PROCEDURES LABEL FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 16, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-4500.

ON CERTAIN TRUCKS USING AN F060T OR F070T FRONT AXLE, THE FRONT WHEEL HUB OUTER BEARING LOCK NUT MAY HAVE BEEN IMPROPERLY TIGHTENED DURING ASSEMBLY, AND AN INSUFFICIENT AMOUNT OF GREASE MAY HAVE BEEN APPLIED TO THE OUTER BEARING.

RiskTHESE CONDITIONS COULD RESULT IN THE OUTER BEARING GENERATING EXCESSIVE HEAT AND/OR BREAKING, CAUSING THE VEHICLE TO BECOME DISABLED. THE EXCESSIVE HEAT COULD CAUSE A FIRE.

FixDEALERS WILL INSPECT THE INNER AND OUTER FRONT WHEEL HUB BEARINGS, AND REPLACE ANY BEARING WITH SIGNS OF DAMAGE. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MITSUBISHI FUSO AT 1-856-467-4500.