1999 Mercury Sable

ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

RiskIF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.

FixDEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.

RiskIF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.

FixDEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.

RiskTRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.

FixDEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.

VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.

RiskIF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.

FixDEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.

RiskIF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

FixDEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.

FRONT SUSPENSION COIL SPRING FRACTURE

Led to recall04V332000

FRONT SUSPENSION COIL SPRING FRACTURE

Led to recall04V332000

FRONT SUSPENSION COIL SPRING FRACTURE

FRONT SUSPENSION COIL SPRING FRACTURE