2005 Glaval Concorde

GLAVAL BUS IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2009 TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

RiskA SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND FIRE.

FixGLAVAL BUS WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON NOVEMBER 10, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR GLAVAL BUS AT 1-574-262-2212.

GLAVAL BUS IS RECALLING 10 MY 2005 CONCORDE TRANSIT BUSES. THE HYDRAULIC BRAKE LINES MAY CONTACT THE TRANSMISSION DIPSTICK TUBE AS THE ENGINE ROCKS.

RiskCONTINUED CONTACT BETWEEN THE BRAKE LINE AND THE DIPSTICK TUBE COULD ABRADE THE BRAKE LINE, CAUSING A LEAK AND LOSS OF BRAKE FLUID WHICH COULD LEAD TO REDUCED BRAKE PERFORMANCE. REDUCED BRAKING PERFORMANCE COULD RESULT IN A CRASH WITHOUT WARNING.

FixDAIMLER TRUCKS IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. PLEASE SEE 09V-114. DAIMLER TRUCKS WILL CORRECT THE CHASSIS IF FOUND TO BE DEFECTIVE. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

GLAVAL BUS IS RECALLING 117 MY 2003-2006 CONCORDE AND MY 2003-2004 STAR CRUISER EQUIPPED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. INSTALLATION OF A FOUR-PIECE SPINDLE NUT SET WITH A THIN SPINDLE NUT MAY LEAD TO DAMAGE OF THE WHEEL END, INCLUDING INCORRECT END PLAY, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.

RiskOUTER WHEEL BEARING FAILURE WILL CAUSE NOISE AND VIBRATION THAT WILL BE NOTICEABLE TO THE DRIVER AND THE ANTILOCK BRAKING SYSTEM (ABS) WARNING LIGHT WILL ILLUMINATE. CONTINUED OPERATION WITH THE ABS WARNING LIGHT ILLUMINATED MAY RESULT IN WHEEL SEPARATION AND A POSSIBLE VEHICLE CRASH.

FixDAIMLER TRUCKS IS HANDLING THE REMEDY FOR THIS CAMPAIGN (PLEASE SEE 08V-137). GLAVAL BUS IS WORKING WITH DAIMLER TRUCKS THE EXISTING FOUR-PIECE SPINDLE SET WILL BE REPLACED WITH A MORE ROBUST NUT SET USING A THICKER, HARDER INNER NUT AND A NEW HUB CAP. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 24, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR GLAVAL BUS AT 574-262-2212.

ON CERTAIN BUSES EQUIPPED WITH SEAT BELTS, THE T-NUT WHICH HOLDS THE SEAT LEG TO THE FLOOR TRACK IS MISSING MACHINED BEVELS.

RiskIN THE EVENT OF A CRASH, WITHOUT THE BEVELS, THE SHARP EDGE COULD COME THROUGH THE FLOOR TRACK INCREASING THE RISK OF INJURY TO SEAT OCCUPANT.

FixOWNERS WILL BE PROVIDED WITH THE NECESSARY PARTS TO REPLACE THE T-NUTS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 24, 2006. OWNERS MAY CONTACT GLAVAL BUS AT 1-800-445-2825.