2004 Freightliner FLD

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.

RiskTHIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

FixDAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.

RiskAN OIL LEAK MAY RESULT IN A FIRE.

FixDAIMLER TRUCKS IS WORKING WITH CATERPILLAR TO REMEDY THESE VEHICLES. PLEASE SEE CATERPILLAR'S DEFECT REPORT 09E-020. CATERPILLAR WILL INSPECT AND REPAIR THE NECESSARY COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 5, 2009. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR DAIMLER TRUCKS AT 1-800-547-0712.

ON CERTAIN TRUCK AND MOTOR HOME CHASSIS EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION.

RiskIF THIS OCCURS, THE VEHICLE COULD SUFFER A LOSS OF STEERING ABILITY, WHICH COULD RESULT IN A CRASH.

FixDEALERS WILL INSPECT AND ATTACH A TENSION COLLAR TO THE STEERING SHAFT TO SECURE THE CONNECTION TO THE YOKE. THE RECALL BEGAN ON NOVEMBER 16, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

ON CERTAIN TRUCKS EQUIPPED WITH 3RD GENERATION CONMET ALUMINUM WHEELS, THE DRUM MOUNTING FLANGE ON THE CONMET TRUTURN BRAKE DRUM MAY HAVE BEEN MANUFACTURED WITH A TAPER FROM THE PILOT HOLE TO THE BARREL OF THE DRUM.

RiskTHIS TAPER MAY CAUSE CRACKING OR FRACTURES OF THE FRONT HUB. THIS COULD CAUSE A CRASH WITHOUT PRIOR WARNING.

FixAFTER FURTHER INVESTIGATION AND TESTING, FREIGHTLINER HAS REVISED THE POPULATION AND THE REMEDY (DECEMBER 22, 2005). THEREFORE, THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

ON CERTAIN TRUCKS, THE BRAKE PEDAL PUSHROD WAS NOT TIGHTENED PROPERLY DURING ASSEMBLY.

RiskLOOSE BRAKE PEDAL PUSHROD JAM NUTS COULD CAUSE LOSS OF CONTROL OF THE VEHICLE AND A CRASH MAY OCCUR.

FixDEALERS WILL ADJUST THE PEDAL PUSHROD. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

ON CERTAIN VEHICLES, THERE IS A DEFECT IN THE INTERAXLE DRIVELINE YOKES. THE BOLT HOLES LOCATED ON THE EARWORK OF THE MALE SHAFT YOKES WERE MANUFACTURED WITH AN OVERSIZED MINOR THREAD DIAMETER.

RiskTHIS CONDITION ALLOWS THE BOLTS USED IN THE HOLES TO BECOME DETACHED WHICH COULD RESULT IN A DRIVELINE SEPARATION. DRIVELINE SEPARATION COULD RESULT IN A VEHICLE CRASH.

FixDEALERS WILL REPLACE THE SUSPECT MALE SHAFT YOKES. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.