1989 Ford Aerostar

VEHICLE DESCRIPTION: MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES OF LOS ANGELES, ORANGE, SAN BERNADINO, SAN DIEGO, RIVERSIDE, VENTURA, SANTA BARBARA, SAN LUIS OBISPO, IMPERIAL, AND KERN), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY), OKLAHOMA, SOUTH CAROLINA, AND TEXAS, AND IN THE U.S. TERRITORIES COVERED BY THE FEDERAL STATUTES. THE UPPER PORTION OF THE FUEL TANK CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS.

RiskIF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

FixDEALERS WILL REPLACE THE FUEL TANK, REGARDLESS OF MILEAGE, THROUGH MARCH 31, 2002. THIS COVERAGE WILL ONLY BE FOR STRUCTURAL CRACKS AT THE TOP OF THE TANK AND WILL NOT INCLUDE OTHER DAMAGE CAUSED BY AN ACCIDENT OR ROAD DEBRIS.

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

RiskLOSS OF BRAKING CAN RESULT.

FixAIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

RiskTHIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

FixDEALERS WILL REPLACE THE IGNITION SWITCH.

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

RiskDRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.

FixREPAIR THE TRANSMISSION WITH A NEW PARK PAWL.

SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.

RiskVEHICLES WOULD NOT COMPLY WITH FMVSS 210.

FixREPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.

THE SECOND ROW RIGHT HAND SEAT ASSEMBLY HAS A TILT FORWARD FUNCTION. A LATCH RETAINS THE SEAT IN THE NORMAL RIDE POSTION, AND THIS LATCH MAY RELEASE UNDER SEVERE FRONTAL IMPACT CONDITIONS, ALLOWING THE SEAT TO PIVOT FORWARD.

RiskIN THE EVENT OF VEHICLE ACCIDENT, THE SEAT COULD PIVOTFORWARD, INCREASING THE RISK OF INJURY TO THE OCCUPANT.

FixREPLACE SEAT PAWL ASSEMBLY WITH A REVISED DESIGN ASSEMBLY.

CRACKED FUEL TANKS

Led to recall98V190000

CRACKED FUEL TANKS

SEAT BELT BUCKLE FAILURE

SEAT BELT BUCKLE FAILURE

PARK PAWL BENDING

Led to recall91V189000