1995 Ducati 916

Ohlins Racing AB (Ohlins) is recalling certain steering dampers kits manufactured with an incorrectly machined bracket. These dampers were sold for use as aftermarket equipment on Yamaha R1, R6, and FZ6, Suzuki TL1000 R and GSX1300R, Honda CB600RR, and Ducati Monster 1000, 748, 848, 916, 996, and 998 motorcycles. Also included are universal steering damper kits with part numbers SD 000 through SD 005. The affected brackets may crack.

RiskIf there is a crack in the steering bracket, at low speeds it may cause the steering to lock, leading to personal injury or a crash.

FixOhlins will notify the distributors and provide their customers with a new bracket. The recall began in November 2013. Owners may contact Ohlins USA at 1-828-692-4525. Note: This recall is an expansion of recall 13E-034.

Ohlins Racing AB (Ohlins) is recalling certain steering dampers kits manufactured with an incorrectly machined bracket. These dampers were sold for use as aftermarket equipment on Yamaha R1, R6, and FZ6, Suzuki TL1000 R and GSX1300R, Honda CB600RR, and Ducati Monster 1000, 748, 848, 916, 996, and 998 motorcycles. Also included are universal steering damper kits with part numbers SD 000 through SD 005. The affected brackets may crack.

RiskIf there is a crack in the steering bracket, at low speeds it may cause the steering to lock, leading to personal injury or a crash.

FixOhlins will notify the distributors and provide their customers with a new bracket. The recall began in November 2013. Owners may contact Ohlins USA at 1-828-692-4525. Note: This recall is an expansion of recall 13E-034.

VEHICLE DESCRIPTION: MOTORCYCLES EQUIPPED WITH A REAR WHEEL HUB SPINDLE. INTERNAL CRACKS MAY BE PRESENT ON THE REAR WHEEL SPINDLE.

RiskTHIS CONDITION COULD CAUSE THE SPINDLE TO FAIL AFFECTING THE CONTROL OF THE MOTORCYCLE, AND COULD RESULT IN A CRASH.

FixDEALERS WILL INSPECT THE REAR WHEEL SPINDLE AND REPLACE IF NECESSARY.

VEHICLE DESCRIPTION: MOTORCYCLES. THE THROTTLE CONTROL LINKAGE PIN WAS NOT LUBRICATED PROPERLY.

RiskTHE ENGINE MAY NOT RETURN TO PROPER IDLE.

FixDEALERS WILL LUBRICATE THE THROTTLE CONTROL LINKAGE PIN USING GREASE CONTAINING MOLYBDENUM DISULPHIDE.

THE TEFLON BUSHING FOR THE THROTTLE CABLE CAN SLIDE OUT OF THE THROTTLE CABLE HOUSING.

RiskTHIS CONDITION CAN CAUSE THE ACCELERATOR TO STICK OPEN PARTIALLY, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

FixDEALERS WILL MODIFY THE THROTTLE CABLE ASSEMBLY BY ELIMINATING THE TEFLON BUSHING INSIDE THE CABLE.

SOME MOTORCYCLES WERE PRODUCED WITHOUT THE APPLICATION OF THE PROPER LOCTITE ADHESIVE ON THE REAR BRAKE DISC AND COUNTER SHAFT CHAIN SPROCKET SCREWS.

RiskTHIS CONDITION CAN POTENTIALLY CAUSE THE BRAKE DISC TO BECOME LOOSE, INTERFERE WITH THE BRAKE CALIPER SUPPORT PLATE, CAUSING NOISE AND REDUCED REAR BRAKE PERFORMANCE INCREASING THE RISK OF AN ACCIDENT.

FixDEALERS WILL REMOVE, INSPECT, CLEAN AND REINSTALL THE REAR BRAKE DISC SCREWS AND COUNTER SHAFT CHAIN SPROCKET SCREWS AND APPLY THE PROPER LOCTITE ADHESIVE.

THE SIDE STAND SPRING PLATE ON THE RETRACTABLE SIDE STAND CAN BREAK ALLOWING THE SIDE STAND TO DROP AND POSSIBLY HIT THE GROUND WHILE THE VEHICLE IS IN MOTION.

RiskTHIS CONDITION COULD AFFECT THE CONTROL OF THE MOTORCYCLE AND INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.

FixDEALERS WILL REPLACE THE SPRING PLATE ON THE AFFECTED MOTORCYCLES.

REAR BRAKE DISC SEPARATION

Led to recall95V109000