2007 Country Coach Allure

ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

RiskTHIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

FixCOUNTRY COACH IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON MAY 3, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR COUNTRY COACH AT 1-800-547-8015.

ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

RiskIF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, OIL AND DEBRIS ON THE ROADWAY AND VEHICLE CRASH.

FixCOUNTRY COACH IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 800-343-7357 OR COUNTRY COACH AT 1-541-998-3720.

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE EQUIPPED WITH MORE THAN THREE AMBER IDENTIFICATION LAMPS LOCATED AT THE TOP AND FRONT OF THE VEHICLE. ALSO, THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AT 45 DEGREES AS SPECIFIED IN THE STANDARD.

RiskTHE FIVE IDENTIFICATION LIGHTS COULD POSSIBLY CAUSE CONFUSION TO ON-COMING MOTORISTS WHO ARE USED TO OBSERVING THREE IDENTIFICATION LIGHTS. THE INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A CRASH.

FixDEALERS WILL REMOVE THE TWO EXTRA IDENTIFICATION LAMPS AND INSTALL FOUR SIDE MARKER LIGHTS, ONE AT EACH CORNER, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 31, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.