1995 BMW 740I

FCP GROTON IS RECALLING CERTAIN STEERING CENTER DRAG LINKS, P/N 32 21 1 096 057, SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AS REPLACEMENT EQUIPMENT FOR MODEL YEAR 1995 THROUGH 2001 BMW 740I, 740IL, AND 750IL PASSENGER VEHICLES. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.

RiskTHIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.

FixFCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.

VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.

RiskTHE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.

FixDEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.

THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.

RiskTHIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.

FixDEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

FUEL SEEPAGE CAN OCCUR BETWEEN A HOSE AND THE METAL FUEL LINE ON EITHER END OF THE HOSE RESULTING IN FUEL ODOR.

RiskFUEL LEAKAGE COULD POTENTIALLY RESULT IN A VEHICLE FIRE.

FixDEALERS WILL REPLACE THE TWO FUEL HOSES, FOUR METAL FUEL LINES AND ASSOCIATED CLAMPS.

THE LOWER SUSPENSION ARM MOUNTING EYE ON THE RIGHT SIDE REAR AXLE HUB CARRIER WAS PRODUCED WITH A CASTING FLAW.

RiskIT IS POSSIBLE THAT THE RIGHT SIDE REAR AXLE CARRIER EYE COULD CRACK AND BREAK WHILE DRIVING CAUSING A LOSS OF CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

FixDEALERS WILL INSPECT THE VEHICLES FOR A CASTING FLAW IN THE RIGHT SIDE REAR AXLE CARRIER AND IF FOUND, REPLACE THE CARRIER.