2005 Blue Bird Conventional

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 ALL AMERICAN, VISION, MICRO BIRD, AND CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 30, 2003 AND MAY 7, 2009. INCORRECT OFFSET LEG BARRIER PADS OR 2/3 SEAT BACK PADS MAY HAVE BEEN INSTALLED. BUSES WITH INCORRECT PADS INSTALLED FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

RiskIN THE EVENT OF A CRASH, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT(S).

FixBLUE BIRD WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 18, 2009. OWNERS MAY CONTACT BLUE BIRD AT 1-478-822-2242.

CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

RiskSHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING MOTORISTS SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

FixBLUE BIRD WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, BLUE BIRD IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, BLUE BIRD WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, BLUE BIRD WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

RiskSHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

FixBLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN 2002-2006 MY BLUE BIRD ALL AMERICAN SCHOOL AND TRANSIT BUSES, CONVENTIONAL SCHOOL BUSES, AND COMMERCIAL SERIES TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 21, 2002, AND FEBRUARY 24, 2005. THESE BUSES ARE EQUIPPED WITH WEBASTO COOLANT HEATERS, MODEL DBW 2010, ASSEMBLED WITH WEBASTO BURNER TUBES, P/N 303046/26533A MANUFACTURED BETWEEN NOVEMBER 2002 AND FEBRUARY 2005. THE STAINLESS STEEL BURNER TUBE IS MADE OUT OF A MATERIAL THAT IS NOT TO SPECIFICATION AND COULD FAIL PREMATURELY.

RiskSHOULD THE BURNER TUBE FAIL, THE COOLANT HEATER COULD OVERHEAT, POSSIBLY RESULTING IN A FIRE.

FixBLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE BURNER TUBES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN MY 2003 THRU 2005 BLUE BIRD MICRO BIRD AND CONVENTIONAL SCHOOL BUSES. THESE BUSES DO NOT HAVE THE TIRE LOAD RANGE ON BOTH THE TIRE INFORMATION LABEL AND CERTIFICATION DECAL AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.

RiskOMISSION OF THE TIRE LOAD RANGE MAY LEAD TO THE INSTALLATION OF TIRES WITH LOAD RANGES NOT APPROPRIATE FOR VEHICLE USE. A FAILURE OCCURRING IN TIRES DUE TO INAPPROPRIATE LOAD RANGE MAY RESULT IN LOSS OF CONTROL OF THE VEHICLE AND A CRASH CAN OCCUR.

FixBLUE BIRD WILL MAIL TO FINAL STAGE MANUFACTURERS, CERTIFICATION DECALS WITH THE TIRE LOAD RATING INDICATED TO ITS CUSTOMERS. THE RECALL BEGAN ON MAY 6, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.