2003 Blue Bird ALL American

BLUE BIRD IS RECALLING 2,203 MODEL YEAR 2003 THROUGH 2010 ALL AMERICAN REAR ENGINE SCHOOL BUSES EQUIPPED WITH OPTIONAL PLUG STYLE VANDAL LOCKS MANUFACTURED FROM JULY 16, 2003 THROUGH APRIL 10, 2009. THE PLUG STYLE VANDAL LOCK IS NOT WIRED TO INHIBIT THE STARTER AT THE IGNITION SWITCH WHEN THE VANDAL LOCK IS IN THE LOCKED POSITION. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

RiskTHE VEHICLES CAN BE STARTED AND DRIVEN EVEN WHEN AN OWNER MAY THINK THEY CANNOT.

FixBLUE BIRD WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 25, 2009. OWNER MAY CONTACT BLUE BIRD AT 1-478-422-2242.

CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.

RiskSHOULD THE BUS SHUT DOWN WHILE IN OPERATION, A VEHICLE CRASH COULD OCCUR.

FixBLUE BIRD WILL NOTIFY ITS OWNERS AND INSTRUCT THEM ON HOW TO REPAIR THE SWITCH. THE RECALL BEGAN ON OCTOBER 19 , 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

RiskSHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

FixBLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

RiskSHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING MOTORISTS SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

FixBLUE BIRD WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, BLUE BIRD IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, BLUE BIRD WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, BLUE BIRD WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN ON AUGUST 12, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN 2001 THROUGH 2005 ALL AMERICAN, COMMERCIAL SERIES, AND Q-BUS SCHOOL AND TRANSIT BUSES EQUIPPED WITH JOHN DEERE 8.1 CNG ENGINES. THE SUBJECT BUSES EQUIPPED WITH THE JOHN DEERE ENGINES MAY SURGE INAPPROPRIATELY DUE TO ERRACTIC OPERATION OF THE AIR THROTTLE IF THE ENGINE IS TAKEN FROM FULL TO ZERO LOAD.

RiskUNEXPECTED ENGINE SURGE COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY.

FixJOHN DEERE WILL NOTIFY BLUE BIRD'S CUSTOMERS AND REPAIR THE ENGINES FREE OF CHARGE. CUSTOMERS ARE BEING INSTRUCTED TO CONTACT JOHN DEERE AT 1-800-JD-ENGINE.

CERTAIN 2002-2006 MY BLUE BIRD ALL AMERICAN SCHOOL AND TRANSIT BUSES, CONVENTIONAL SCHOOL BUSES, AND COMMERCIAL SERIES TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 21, 2002, AND FEBRUARY 24, 2005. THESE BUSES ARE EQUIPPED WITH WEBASTO COOLANT HEATERS, MODEL DBW 2010, ASSEMBLED WITH WEBASTO BURNER TUBES, P/N 303046/26533A MANUFACTURED BETWEEN NOVEMBER 2002 AND FEBRUARY 2005. THE STAINLESS STEEL BURNER TUBE IS MADE OUT OF A MATERIAL THAT IS NOT TO SPECIFICATION AND COULD FAIL PREMATURELY.

RiskSHOULD THE BURNER TUBE FAIL, THE COOLANT HEATER COULD OVERHEAT, POSSIBLY RESULTING IN A FIRE.

FixBLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE BURNER TUBES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." ONE OR MORE OF THE BOLTS ATTACHING THE DRIVER'S PLATFORM TO THE FLOOR STRUCTURE WAS OMITTED.

RiskTHE REAR OF THE DRIVER'S PLATFORM MAY NOT BE PROPERLY RETAINED IN THE EVENT OF A CRASH WHICH COULD INCREASE THE RISK OF INJURY OR DEATH TO PASSENGERS.

FixBLUE BIRD WILL NOTIFY ITS CUSTOMERS AND INSPECT AND REPAIR THE AFFECTED UNITS. OWNER NOTIFICATION BEGAN ON NOVEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.

ON CERTAIN SCHOOL BUSES EQUIPPED WITH OPTIONAL SEAT BELTS OR SEAT BELT "READY" SEATS, SOME BELTS WERE INSTALLED WITH ONLY TWO BOLTS RATHER THAN THE REQUIRED THREE (3) BOLTS.

RiskTHESE SEATS COULD DETACH FROM THE WALL SIDE ATTACHMENT POINTS IN THE EVENT OF A VEHICLE CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.

FixBLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO INSTALL THE MISSING BOLT FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO ON NOVEMBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

SCHOOL BUS STALLS

Led to recall05V382000