2001 Blue Bird ALL American

CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.

RiskSHOULD THE BUS SHUT DOWN WHILE IN OPERATION, A VEHICLE CRASH COULD OCCUR.

FixBLUE BIRD WILL NOTIFY ITS OWNERS AND INSTRUCT THEM ON HOW TO REPAIR THE SWITCH. THE RECALL BEGAN ON OCTOBER 19 , 2005. OWNERS MAY CONTACT BLUE BIRD AT 478-822-2242.

CERTAIN 2001 THROUGH 2005 ALL AMERICAN, COMMERCIAL SERIES, AND Q-BUS SCHOOL AND TRANSIT BUSES EQUIPPED WITH JOHN DEERE 8.1 CNG ENGINES. THE SUBJECT BUSES EQUIPPED WITH THE JOHN DEERE ENGINES MAY SURGE INAPPROPRIATELY DUE TO ERRACTIC OPERATION OF THE AIR THROTTLE IF THE ENGINE IS TAKEN FROM FULL TO ZERO LOAD.

RiskUNEXPECTED ENGINE SURGE COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY.

FixJOHN DEERE WILL NOTIFY BLUE BIRD'S CUSTOMERS AND REPAIR THE ENGINES FREE OF CHARGE. CUSTOMERS ARE BEING INSTRUCTED TO CONTACT JOHN DEERE AT 1-800-JD-ENGINE.

CERTAIN 1998 THROUGH 2002 BLUE BIRD ALL AMERICAN, TC2000 SCHOOL AND TRANSIT BUSES, AND COMMERCIAL SERIES BUSES EQUIPPED WITH CUMMINS ISB DIESEL ENGINES. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.

RiskSHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.

FixCUSTOMERS WILL BE NOTIFIED BY CUMMINS TO BRING THEIR VEHICLES TO AN AUTHORIZED DEALER TO HAVE THE FUEL LIFT PUMP REPLACED FREE OF CHARGE. FOR MORE INFORMATION, CUSTOMERS MAY CONTACT CUMMINS AT 1-800-DIESELS.

ON CERTAIN REAR ENGINE (A3RE) SCHOOL BUSES, THE TYPE AND LOCATION OF THE FASTENERS USED TO RETAIN THE SEAT BELT IN THE LAST ROW OF SEATS DOES NOT CONFORM TO BLUE BIRD ENGINEERING SPECIFICATIONS.

RiskTHIS INSTALLATION MAY NOT ADEQUATELY RETAIN SEAT BELTS IN THE EVENT OF A SEVERE CRASH.

FixBLUE BIRD WILL PROVIDE ITS DISTRIBUTORS AND OWNERS THE PARTS AND INSTRUCTIONS TO INSTALL THE CORRECT FASTENERS FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN NOVEMBER 20, 2003. OWNERS WHO DO NOT RECEIVE THE PARTS AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

ON CERTAIN SCHOOL BUSES EQUIPPED WITH OPTIONAL SEAT BELTS OR SEAT BELT "READY" SEATS, SOME BELTS WERE INSTALLED WITH ONLY TWO BOLTS RATHER THAN THE REQUIRED THREE (3) BOLTS.

RiskTHESE SEATS COULD DETACH FROM THE WALL SIDE ATTACHMENT POINTS IN THE EVENT OF A VEHICLE CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.

FixBLUE BIRD WILL FURNISH TO DISTRIBUTORS AND OWNERS, PARTS AND INSTRUCTIONS NECESSARY TO INSTALL THE MISSING BOLT FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO ON NOVEMBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, "SCHOOL BUS BODY JOINT STRENGTH." ONE OR MORE OF THE BOLTS ATTACHING THE DRIVER'S PLATFORM TO THE FLOOR STRUCTURE WAS OMITTED.

RiskTHE REAR OF THE DRIVER'S PLATFORM MAY NOT BE PROPERLY RETAINED IN THE EVENT OF A CRASH WHICH COULD INCREASE THE RISK OF INJURY OR DEATH TO PASSENGERS.

FixBLUE BIRD WILL NOTIFY ITS CUSTOMERS AND INSPECT AND REPAIR THE AFFECTED UNITS. OWNER NOTIFICATION BEGAN ON NOVEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 478-822-2242.

ON CERTAIN SCHOOL AND TRANSIT BUSES EQUIPPED WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AM-SAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.

Risk IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY.

FixOWNERS WILL BE PROVIDED A SNAP-ON "OVER-COVER" TO PREVENT THE SEAT BELT COVER FROM SEPARATING. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR ABOUT SEPTEMBER 27, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE STANDARD NO. 101, "CONTROLS AND DISPLAYS." THIS STANDARD REQUIRES SPECIFIC LABELING FOR "ENGINE START" AND "ENGINE STOP." THE WORDING OF THE LABELS ON THESE VEHICLES DO NOT MEET THE REQUIREMENTS OF THE STANDARD.

RiskTHE OPERATOR COULD PLACE THE ENGINE SWITCH IN A POSITION OTHER THAN THAT INTENDED, INCREASING THE RISK OF A CRASH.

FixOWNERS WILL BE PROVIDED WITH NEW DECALS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN AUGUST 29, 2002. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.

SCHOOL BUS STALLS

Led to recall05V382000