1998 Amtran RE

CERTAIN COMMERCIAL BUSES EQUIPPED WITH T-SLIDE OVAL WINDOWS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." INCORRECT SIDE EMERGENCY EXIT WINDOWS WERE INSTALLED.

RiskPASSENGERS COULD BE PREVENTED FROM EXITING THE BUS, WHICH COULD RESULT IN PERSONAL INJURY OR DEATH.

FixDEALERS WILL REPLACE THE WINDOWS. OWNER NOTIFICATION BEGAN DECEMBER 18, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-843-5615.

CE MODEL SCHOOL BUSES WHICH FAIL TO COMPLY TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. THE ROOF TOP SHEET MAY BE IMPROPERLY LOCATED, REDUCING THE MATERIAL EDGE DISTANCE AT THE RIVET LINE.

RiskIN THE EVENT OF A VEHICLE CRASH, THE JOINT STRENGHT COULD FAIL POSSIBILY RESULTING IN INJURIES TO THE VEHICLE OCCUPANTS.

FixIC WILL NOTIFY ITS CUSTOMERS AND WILL PROVIDE INSPECTION AND REPAIR INSTRUCTION. THE RECALL BEGAN ON JANUARY 25, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CUSTOMER SERVICE AT (WE DO NOT YET HAVE A TELEPHONE NUMBER FOR THIS CAMPAIGN.)

VEHICLE DESCRIPTION: CERTAIN SCHOOL AND TRANSIT BUSES WERE BUILT WITH A POOR QUALITY HEATER/DEFROSTER BLOWER SWITCH. IN SOME CASES THIS HAS CAUSED THE MELTING OF THE HEATER HARNESS CONNECTOR AT THE SWITCH TERMINALS OR THE HIGH-SPEED WIRE INSULATION AT THE CONNECTOR. ALSO, SOME OF THE UNITS HAD IMPROPER CIRCUIT PROTECTION SIZE INSTALLED IN THE HEATER DEFROSTER CIRCUIT.

RiskIF AN OPERATOR DETECTS SMOKE OR THE SMELL OF MELTING WIRE INSULATION FROM THE BLOWER CONTROL PANEL, THE OPERATION OF THE HEATER/DEFROSTER AT HIGH SPEED SHOULD BE DISCONTINUED UNTIL THE REPAIR IS MADE.

FixOWNERS WILL BE PROVIDED WITH INSTRUCTIONS AND PARTS TO REPLACE THE SWITCH AND SWITCH HARNESS WITH A NEW SWITCH, SWITCH HARNESS, RELAY AND RELAY HARNESS. FOR THE RE UNITS BUILT PRIOR TO JANUARY 1, 1999, THE KIT WILL ALSO INCLUDE A 20-AMPERE MANUAL CIRCUIT BREAKER. OWNER NOTIFICATION BEGAN DECEMBER 15, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 800-843-5615.

VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES. SOME CERTIFICATION LABELS DISPLAYED THE INCORRECT TIRE PRESSURE FOR THE TIRE SPECIFIED TO MEET THE GROSS AXLE WEIGHT RATING FOR THE FRONT AND/OR REAR AXLES. THIS DOES NOT MEET THE CERTAIN REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS," AND 49 CFR PART 567, "CERTIFICATION."

RiskUNDER OR OVER-INFLATED TIRES CAN CAUSE OR CONTRIBUTE TO PREMATURE TIRE FAILURE, POSSIBLY RESULTING IN A SUDDEN BLOWOUT OR OTHER FAILURE WHICH COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE.

FixNEW CERTIFICATION LABELS ARE BEING PROVIDED TO OWNERS. OWNER NOTIFICATION BEGAN MARCH 16, 2001. OWNERS WHO DO NOT RECEIVE THE FREE CERTIFICATION LABEL WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-993-7686.

VEHICLE DESCRIPTION: SCHOOL BUSES BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU). THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.

RiskTHIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.

FixDEALERS WILL REPLACE THE ABS ECU.

VEHICLE DESCRIPTION: SCHOOL BUSES. SOME REAR EMERGENCY EXIT WINDOWS DO NOT MEET THE VERTICAL OPENING REQUIREMENTS AS SPECIFIED BY FMVSS NO. 217, "BUS WINDOW RETENTION AND RELEASE."

RiskIN THE EVENT OF A CRASH, PERSONAL INJURY COULD OCCUR.

FixOWNERS WILL BE PROVIDED WITH INSTRUCTIONS ON HOW TO IDENTIFY THE DEFECT AND REPAIR PROCEDURES. IF THE OWNER PREFERS, AN AMTRAN DEALER CAN PERFORM THE REMEDY FOR THEM.

VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH FLIP SEATS AT THE EMERGENCY EXITS. THE SEAT CUSHION HINGE ON THE COMBINATION FLIP SEAT IS LOCATED IN SUCH A MANNER THAT IT IS WITHIN EASY REACH OF THE PASSENGER SITTING IN THE SEAT LOCATED BEHIND THE COMBO FLIP SEAT.

RiskTHE HINGES ON THE COMBO FLIP SEAT CAN CAUSE A PINCHING CONDITION, RESULTING IN PERSONAL INJURY.

FixOWNERS WILL BE NOTIFIED AND SENT KITS TO REMEDY THESE SEATS.

STEERING SHAFT BOLT BINDS ON COVER

Led to recall03V264000